Please select To the mobile version | Continue to access the desktop computer version

zeusbtc bbs

 Forgot password?
 Sign up now
Search
View: 442|Reply: 8

How to Repair Whatsminer Power Supply?

[Copy link]

65

Threads

65

Posts

246

Credits

Moderator

Rank: 7Rank: 7Rank: 7

Credits
246
Post time 2021-11-20 13:55:03 | Show all posts |Read mode
How to repair Whatsminer power supply?
I. Upgrade power unlock firmware
There will be no voltage output when powering on the power supply alone. Connect a control board to the power supply, and then upgrade the special firmware for the control board. Test after restarting, the power supply will have average voltage output.
II. Abnormal voltage it
For this faulty power supply, let's first remove the power screw. Then take out the circuit board, remove the fan. I use a fluke 15b+ multimeter to measure whether the positive and negative poles of the output terminal are short-circuited. If there is no short circuit, measure whether there is voltage input in the front section. Generally, the input voltage is measured on the two pins of large capacitance.
Measure whether the input voltage is about 420V. At present, only about 300V is measured. It indicates that PFC has no pressure rise. To ensure the safety t is necessary to discharge the capacitor and conduct the subsequent step measurement.
First, check the control chip circuit for short circuits or faulty soldering. VCC powers the control board chip circuit, so detecting whether the VCC power supply is regular.
Measure whether the diode transistor of the VCC circuit is standard. If it didn't work, it should be replaced. However, the VCC voltage is constantly beating after power on measurement, and the VCC circuit doesn’t work. Therefore, discharge the Capacitor after power off because VCC rectifies through multiple diodes and outputs multiple sets of voltages. Therefore, it is necessary to measure whether each rectifier diode works.
It is the short circuit of the filter capacitor after the measure. It shows that there is something wrong with the rectifier output. The measuring triode works. The diode is on the front side and is covered by glue. It needs replacing by prying the glue, replacing it with a new diode. Measure after the replacement to confirm that there is no short circuit.
Finally, perform the installed power-on test to confirm that the output is average and the fault is repaired.
III. The fan is running normally, and the output voltage is abnormal
One probe is to the ground, and the other measures the same pin positions of four driver chips and compares them. The value of the same pin of the usual chip is the same. If there is a big difference between the pin position and the ground value, the IC drive circuit may be short-circuited. If there is no sign of burning on the surface of the chip, it may be that the MOS transistor driven by it is short-circuited, remove the heat sink of the MOS tube.
Compare and measure the 4th pin (control pin) of the MOS transistor with the fluke 15b+ multimeter's diode. Find out which MOS transistor is short-circuited. The fourth leg of the normal tube is about 05.7V. Switch the fluke 15b+ multimeter to resistance and measure the abnormal group of MOS transistor pin 4. If there is more than one damage, they need replacing.
IV. Voltage output is getting lower and lower
If the fan doesn't work, check whether the fan cable is plugged correctly. Or observe whether the fan speed is too fast.
Due to the high temperature, the fan speed is too fast. The power supply is locked to self-protect, So there is no output. Check the drive circuit of the fan, whether the temperature sensing wires on the four heat sinks are loose. The miner's error is a fan problem or a temperature problem. Check the related lines. If there is no problem with the temperature control on the heat sink, something could be wrong with the chip program. You might have to reset the firmware.


ASIC Miner Repair Toturials and Guides
Reply

Use magic Report

3

Threads

652

Posts

1403

Credits

Gold member

Rank: 6Rank: 6

Credits
1403
Post time 2022-8-29 01:13:46 | Show all posts
Hello! I just wish to give an enormous thumbs up for the nice info you've got right here on this post. I will probably be coming back to your weblog for more soon!        Keepa
Reply

Use magic Report

3

Threads

652

Posts

1403

Credits

Gold member

Rank: 6Rank: 6

Credits
1403
Post time 2022-8-29 01:21:18 | Show all posts
I must say, I thought this was a pretty interesting read when it comes to this topic. Liked the material. . . . .        Keepa
Reply

Use magic Report

3

Threads

652

Posts

1403

Credits

Gold member

Rank: 6Rank: 6

Credits
1403
Post time 2022-8-29 01:24:52 | Show all posts
Its as if you had a great grasp on the subject matter, but you forgot to include your readers. Perhaps you should think about this from more than one angle.        Tech Elevator
Reply

Use magic Report

3

Threads

652

Posts

1403

Credits

Gold member

Rank: 6Rank: 6

Credits
1403
Post time 2022-8-29 01:28:07 | Show all posts
If your looking for Online Illinois license plate sticker renewals then you have need to come to the right place.We offer the fastest Illinois license plate sticker renewals in the state.        Tech Elevator
Reply

Use magic Report

3

Threads

652

Posts

1403

Credits

Gold member

Rank: 6Rank: 6

Credits
1403
Post time 2022-8-29 01:53:14 | Show all posts
Here at this site really the fastidious material collection so that everybody can enjoy a lot.        FlatIron School
Reply

Use magic Report

3

Threads

652

Posts

1403

Credits

Gold member

Rank: 6Rank: 6

Credits
1403
Post time 2022-8-29 01:55:14 | Show all posts
Wow, happy to see this awesome post. I hope this think help any newbie for their awesome work. By the way thanks for share this awesomeness from        eCom Cash Crusher
Reply

Use magic Report

3

Threads

652

Posts

1403

Credits

Gold member

Rank: 6Rank: 6

Credits
1403
Post time 2022-8-29 01:58:26 | Show all posts
Amazing knowledge and I like to share this kind of information with my friends and hope they like it they why I do        FlatIron School
Reply

Use magic Report

0

Threads

1

Posts

4

Credits

Novice

Rank: 1

Credits
4
Post time 2022-9-15 17:01:38 | Show all posts
With different levels and maps as well as racing with people all over the world, the adventure stickman boost game not only gives you moments of relaxation, but also increases the competition to become better not only in the game, but also in real life. What's more, with beautiful, eye-catching graphics as well as other great effects, all of which promises to bring you great moments.
Reply

Use magic Report

You have to log in before you can reply Login | Sign up now

Points Rules

Privacy Policy Terms of Service
Quick Reply To Top Return to the list